Reliant FVIR GAS WATER HEATER Operations Instructions

AP16874 (05/13)! FOR YOUR SAFETY!— Do not store or use gasoline or other flammable vapors or liquids or other combustible materials in the vicinity

10Installing the water heaterA new combination temperature and pressure relief valve, complying with the Standard for Relief Valves and Automatic Gas

11WARNING: DO NOT attempt to convert this water heater for use with a different type of gas other than the type shown on the rating plate. Such conver

12Installing the water heaterThe water heater must be installed with the factory supplied draft hood in place.VentingVent connectors must be attached

13Installing the water heater V Vent Terminal X Air Supply Inlet Area Where Terminal Is Not PermittedU

14For increased energy efficiency, some water heaters have been supplied with two 24” sections of pipe insulation.Please install the insulation, accor

15Installing the water heater DO ❑ DO check inlet gas pressure to ensure that it is within the range specified on the rating plate. ❑ DO provide

16Installation ChecklistA. Water Heater LocationB. Water SupplyC. Gas SupplyD. Relief ValveE. Venting ❑ Close to area of vent. ❑ Indoors and pr

17Tee fitting for vertical hot water supply lines.Hot water supply to houseFrom HOT outlet on water heaterHot water supply to heating unitSupplem

18Lighting the water heater Before operating this water heater, be sure to read and follow the instructions on the label pictured below and all other

19Time/Temperature Relationship in Scalds Water Temperature Time To Produce a Serious Burn 120°F More than 5 minutes 125°F 11/2 to 2 minutes 130

2Care and CleaningDraining ... 21Maintenance ... 21Burner Inspection ... 22Extended Shut-Down ...22Safety InformationS

20Operating the water heaterWater Temperature SettingMaximum water temperatures occur just after the burner has shut off. To determine the water tempe

21Care and cleaning of the water heaterDraining the Water Heater!CAUTION: Shut off gas to the water heater at the gas control (thermostat) gas cock or

22Venting System InspectionThe water heater’s internal flue must be inspected annually to be certain it is clean by removing the draft hood and flue b

23Before You Call For ServiceTroubleshooting TipsSave time and money! Review the charts on the following pages first and you may not need to call for

24Problem Possible Causes What To DoRumbling noise Scale and sediment  Clean tank. in tank.Relief valve Pressure build up  This is an una

25Notes:

26Notes:

27Burner Access Door AssemblyBurner Access Door GasketBurnerPilot Assembly ScrewPilot Bracket ScrewsPilot BracketPilot Tube ClipsBurner Hex NutsPilot

28IF YOU NEED SERVICE1. Should you have any questions about your new water heater, or if it requires adjustment, repair, or routine maintenance, it i

3Be sure to read and understand the entire Use and Care Manual before attempting to install or operate this water heater. It may save you time and mon

4The chart shown above may be used as a guide in determining the proper water temperature for your home.DANGER: Households with small children, disabl

5IMPORTANT SAFETY INFORMATIONREAD ALL INSTRUCTIONS BEFORE USINGLP and Natural gas have an odorant added to aid in detecting a gas leak. Some people ma

6IMPORTANT SAFETY INFORMATIONREAD ALL INSTRUCTIONS BEFORE USING!WARNING!For your safety, the information in this manual must be followed to minimize t

7Installing the water heaterThis water heater must be installed in accordance with these instructions, local codes, utility company requirements, and/

8Installing the water heaterCombustion and Ventilation AirProper operation of the water heater requires air for combustion and ventilation. Provisions

9Thermal ExpansionDetermine if a check valve exists in the inlet water line. Check with your local water utility company. It may have been installed i